If your RV roof started leaking after a storm in Port St Lucie, we handle full rv roof leak repair fast, from water intrusion testing to permanent reseals and membrane replacement. At in , , we find the entry point, dry the deck, replace any rotten substrate, and reseal or re-skin the roof so it passes a hose test the same day.
Last updated: March 2026
TL;DR: Storm popped a seam or ripped your RV roof? We fix leaks same day in most cases. Expect $189 to $750 for patches and seam reseals, and $2,900 to $7,800 for full membrane replacement. Call to schedule or request a free estimate. We’re licensed, insured, and local to St. Lucie County.
Professional inspection on a storm-damaged EPDM roof before testing and reseal.
Fast, local help for RV roof leaks after wind, hail, or falling limbs
We’ll come to your site in Port St Lucie, St. Lucie West, Tradition, or near the Botanical Gardens, run a pressure and hose test, and stop the active leak first. Then we rebuild what the storm damaged. That can be a lifted termination bar, cracks in Dicor sealant, punctures from branches, or seam separation near your front cap. We stock EPDM and TPO materials, Eternabond, Dicor self-leveling lap sealant, urethane sealants for cap seams, and vent/AC gaskets on our mobile trucks.
We’ve done 3,500+ roof jobs across the Treasure Coast. We know how PSL storms drive rain sideways under trim. We also know insurers in Florida want photos, meter readings, and a line-item estimate. You’ll get all three from us the same day, plus documented drying times so claims don’t stall.
Fresh self-leveling sealant around a skylight after removing failed caulk and rusted screws.
What rv roof leak repair includes after storm damage
We treat storm leaks in a couple phases. First, stop the active water entry. Then, fix the root cause, not just the symptom. Expect us to:
- Pressure test and hose test, 30 to 45 minutes, to map the intrusion. Pull and replace failed sealant. No smearing over old silicone. We remove it clean with plastic scrapers and mineral spirits or Xylene depending on the membrane type. Replace rusted fasteners with stainless where it matters, especially on termination bars and ladder mounts. Patch EPDM/TPO punctures using Primer and Eternabond or heat-welded patches on TPO if manufacturer allows. Reseal all terminations, caps, vents, antennas, and skylights with compatible products. Dicor for EPDM, Alpha Systems for newer TPO, and Geocel 2300 on verticals.
On bigger hits, we replace wet OSB or luan underlayment, check the aluminum trusses for deformation, and re-skin with a new membrane. If water tracked into a slide, we service the bulb seals and slide topper too. We’ve seen water wick 6 feet past the visible hole. Hidden damage is common. We’ll show you moisture meter readings so you aren’t guessing.
According to NOAA’s National Hurricane Center, the Treasure Coast sees frequent tropical impacts and heavy rain bands that drive water against RV caps and seams. That’s why we pressure test everything, not just the obvious leak point.
Costs in Port St Lucie for storm-related rv roof leak repair
Here’s what we charge in PSL and St. Lucie County. Straight answers, no vague “call for pricing.”
- Leak diagnostic with pressure and hose test: $89 to $129, waived with approved repair. Small puncture patch with Eternabond and compatible primer: $189 to $450. Full perimeter cap and accessory reseal with Dicor/Alpha Systems: $395 to $750. Replace one roof vent with new butyl tape and sealant: $225 to $325 parts and labor. AC gasket replacement and pan cleanout: $189 to $279 per unit. Slide-out roof patch and side seal reset: $650 to $1,400 depending on length. Partial deck repair (wet substrate under membrane): $450 to $1,200 per section. Full membrane replacement (EPDM or TPO): $2,900 to $7,800 based on length and options. Emergency or same day rv repair dispatch fee: $129 within 20 miles of Crosstown Parkway, PSL.
We honor written estimates for 30 days. We’re licensed, insured, and we back roof leak repairs with a 12 to 36 month workmanship warranty depending on scope. Want a line-item quote texted today? Call .
How we fix a storm-damaged RV roof, step by step
You asked for clear steps. Here’s the process we follow on 90% of storm leaks.
1) Document and test
Photograph every suspect seam and accessory. Pressure test, then hose test specific zones to trace water paths. Insurers love this documentation.
2) Remove failed materials
Scrape off old sealant, lift loose tape, and pull corroded screws. Clean with the right solvent for EPDM or TPO. No silicone contamination allowed.
3) Dry and repair substrate
Open the membrane if the deck is wet. Replace rotten luan or OSB. Treat minor mold with EPA-registered cleaner. Re-glue membrane or prep for patch.
4) Patch and reseal
Prime, then apply Eternabond on patches. Reseal caps, vents, antennas, and skylights with Dicor or Alpha Systems products. Replace AC gaskets if crushed.
5) Final test and report
Hose test again for 10 to 15 minutes. Provide photos, moisture readings, and parts list. You’ll see the before and after side by side.
We’ve done this on Winnebago, Keystone, Forest River, Grand Design, Tiffin, and Thor. Honestly, we’d skip bargain sealants that promise “lifetime fix” in one coat. Not even close.
Eternabond patch set over primed TPO where a limb punctured the roof skin.
Mobile rv repair in PSL: We come to you after the storm
Can’t move the rig? We’ll bring the shop to you. Our mobile rv repair trucks cover Port St Lucie, Fort Pierce, Jensen Beach, Stuart, Palm City, and Vero. Typical arrival time is 60 to 120 minutes after you call during business hours. After-hours emergency rv repair is available, too. We carry a ladder rack, shop vacs, fans, a heat gun, meters, and sealants so we can start right away in your driveway, storage lot, or campsite at Savannas Preserve State Park.
We’re 15 minutes to St. Lucie West, 20 minutes to Tradition Square, and 25 to PSL Botanical Gardens on a normal day. After a storm, roads get messy. We’ll give you an honest ETA, not a fake window.
If you need other help while we’re there, we also handle rv awning repair, rv slide out repair, rv leveling jack repair, and rv electrical repair. Check our dedicated pages for details: mobile service on our rv roof repair page, seasonal rv water leak repair checks, or request rv generator repair if your genset flooded.
Internal links you might want:
- Full roof services with photos at /rv-roof-repair Our mobile rv repair coverage at /mobile-rv-repair Leak testing methods explained at /rv-water-leak-repair Appliance fixes like rv ac repair at /rv-ac-repair City coverage and drive times at /service-area/port-st-lucie
The storm patterns we see in St. Lucie County and how they ruin RV roofs
Gusty squalls push rain under the front cap and ladder mounts. Hail won’t always puncture EPDM, but it crushes old lap sealant and opens micro fissures around skylights. Oak and palm debris slice TPO near edges. And those pretty slide toppers? They act like nets. Water piles up and runs into the side seal.
We had a couple in St. Lucie West last August. Wind lifted the rear termination bar, then rain tracked forward under the membrane and soaked the mid-deck. No staining inside for two weeks. By the time we opened it up, 8 square feet of luan was toast. The fix took 5 hours and saved the ceiling panels. They thought a bead of caulk would do it. We see folks try that all the time and it just traps moisture. Bad move.
For storm stats, NOAA’s National Weather Service Melbourne office tracks Treasure Coast rain rates and wind gusts. Their advisories explain why a 40 mph gust can still push water under a loose seam. Useful reading before hurricane season.
Insurance and documentation for RV roof leaks after storms
We photograph everything, tag each image, and provide moisture meter and thermal camera shots on request. You’ll get a line-item estimate with parts by brand and SKU. The claim adjusters in Florida want proof that the leak came from wind or flying debris, not “wear and tear.” We help you make that case without padding anything.
We keep records of:
- Entry point photos and hose test zones. Fastener corrosion and sealant failures by location. Deck moisture readings with date and time stamps. Warranty info on products used, like Dicor or Alpha Systems.
We’re not fans of overcoating a soaked deck just to get a “quick check.” If the substrate is wet, we open it. If the membrane is shot, we say so. You’ll always know the real fix vs the band-aid.
For product specs and compatibility, we follow manufacturer guidance from Dicor Products and Alpha Systems and keep their tech sheets on hand.
Moisture meter reading recorded for insurance, showing dry values after repairs.
Maintenance tips so you don’t fight the same leak next storm
Want fewer roof surprises? Here’s what works in PSL weather.
- Inspect and clean every 90 days. Salt air and sun beat sealants. Takes 30 to 45 minutes. Reseal suspect areas before hurricane season, not after. Budget $189 to $395 for a preventative reseal. Replace AC gaskets every 5 to 7 years. They compress and create sneaky leaks. Keep slide toppers tensioned and clear of debris. Pine needles are leak magnets. Cover or store under shade when possible. UV eats lap sealant faster than you’d think.
We can set you up on a twice-a-year roof service plan. Most rigs land in the $199 to $329 range per visit, and it includes a written report with photos. Worth every penny.
Other RV systems we can fix while we’re on the roof
Storm leaks don’t always ride alone. We often find a wet converter bay, tripped GFCIs, or an AC that short-cycled. If you need rv appliance repair right away, we do:
- rv air conditioner repair and seasonal service rv furnace repair for soaked igniters rv refrigerator repair after off-level parking rv water heater repair and anode replacement rv plumbing repair and PEX fitting swaps rv electrical repair for corroded connections rv generator repair and carb cleanouts rv solar repair and battery repair after water exposure
If you’re searching “rv repair near me” or “camper repair near me,” we’re already nearby and can knock out a punch list in one visit.
FAQ: Port St Lucie RV roof leak repair after storms
How much does rv roof leak repair cost in Port St Lucie?
Small puncture patches run $189 to $450. Full reseal of caps and accessories lands between $395 and $750. Deck repairs start at $450 per section. Full membrane replacement ranges from $2,900 to $7,800 depending on length and components. We waive the $89 to $129 diagnostic if you approve the repair.
Can you do same day rv repair after a storm?
Yes. We offer same day and emergency rv repair in PSL, Fort Pierce, Jensen Beach, and Stuart. Our emergency dispatch fee is $129 within 20 miles. Most leaks are stabilized in one visit, with a full fix completed that day unless the deck is saturated and needs extra dry time.
What materials do you use for rv roof leak repair?
We stock Dicor self-leveling lap sealant for EPDM, Alpha Systems sealants for TPO, Geocel 2300 for vertical seams, Eternabond RoofSeal tape, butyl tape, stainless fasteners, and AC gaskets. On TPO, we use approved primers and, where appropriate, heat-weld patches following brand guidance.
Do you work with insurance for storm damage?
We don’t file claims for you, but we document everything insurers want: entry point photos, pressure and hose test results, moisture readings, and a detailed, line-item estimate. Most carriers accept our reports because they’re specific and include product names and timestamps.
How long does an rv roof leak repair take?
Diagnostics take 30 to 45 minutes. A small patch and reseal is 1.5 to 3 hours. Slide roof and seal work often takes 2 to 4 hours. Deck repairs add 2 to 5 hours depending on area. A full membrane replacement is typically 1 to 2 days, weather permitting.
Can you repair leaks at my storage lot or campsite?
Absolutely. We’re a mobile rv repair shop. We service homes, storage facilities along US-1, and parks near Savannas Preserve State Park. We carry ladders, fans, and all sealants onboard. If the site has strict rules, we clear it with management first.
What’s the warranty on your roof leak repairs?
We back patches and reseals with a 12-month workmanship warranty. Deck repairs and partial re-skins get 24 months. Full membrane replacements carry up to 36 months on workmanship plus the manufacturer’s product warranty. You’ll have it in writing on your invoice.
How do I prevent future roof leaks in PSL weather?
Inspect quarterly, especially before hurricane season. Keep sealant fresh, AC gaskets healthy, and slide toppers clean. Budget $199 to $329 for our maintenance visit with photos. We find small issues early so storms don’t turn them into big ones.
Is mobile rv repair more expensive than shop work?
Not for roof leaks. Our mobile rates match shop labor, and you skip towing or driver fees. There’s a modest service call that we credit back on larger repairs. Most Port St Lucie customers save time and money by letting us come to them.
Do you repair rv awnings, jacks, and slides damaged by wind?
Yes. We handle rv awning repair, rv leveling jack repair, and rv slide out repair. We can pair these with your roof service so you don’t pay two trip charges. Ask for a bundled estimate.
Why choose for storm-related rv roof leak repair
We’re local to Port St Lucie and the Treasure Coast. We’ve repaired 1,247 storm-related roof leaks in the rv repair psl last 5 seasons, and we’ve seen every weird path water can take under a cap seam. We carry manufacturer-approved products, test every repair under running water, and show you moisture meter readings before we leave. Our reviews average 4.9 stars across 600+ jobs. We’re licensed, insured, and we stand behind our work.
We’re also straight shooters. If a $279 gasket stops the drip, we won’t pitch a $5,000 re-skin. If the deck is mush, we’ll tell you and show you why.
If you like reading specs, check Dicor Products technical data and Alpha Systems roofing guides. If you want it fixed today, call us.
CTA: Call for emergency or same day rv repair. Or request a free estimate through our contact form. We serve daily.
Complete reseal and patch set. Passed a 15-minute hose test without a drip.
Service area and drive times around Port St Lucie
We cover Port St Lucie, St. Lucie West, Tradition, Fort Pierce, Jensen Beach, Stuart, Palm City, and Vero Beach. We’re about 10 minutes from I-95 exits, 15 to 20 minutes to Tradition Square, and 25 minutes to the PSL Botanical Gardens depending on traffic. St. Lucie County, Martin County, and the Treasure Coast are our backyard. If you’re near Crosstown Parkway or US-1, you’re in our same day zone.
For ongoing service, see our local page with maps and timing: service in Port St Lucie, our Fort Pierce route, and expanded hours during storm season.
Ready to stop that leak?
Call now. Ask for a free estimate and a same day slot. We’ll test it, fix it, and water test it again. If you need extra help with rv ac repair, rv refrigerator repair, rv water heater repair, or rv plumbing repair while we’re there, we’ve got you covered. You’ll get photos, clear pricing, and a warranty in writing.
Bottom line: rv roof leak repair after storm damage needs testing, the right products, and someone who’s done this hundreds of times. That’s us. We fix that.
Keywords we service daily: mobile rv repair, emergency rv repair, same day rv repair, motorhome repair near me, rv service near me, rv water leak repair, rv roof repair, rv roof leak repair, rv slide out repair, rv leveling jack repair, rv awning repair, rv electrical repair, rv generator repair, rv solar repair, rv battery repair.
Internal links referenced above:
- Roof services and gallery at /rv-roof-repair On-site help at /mobile-rv-repair Leak detection details at /rv-water-leak-repair Cooling issues solved at /rv-ac-repair Port St Lucie coverage at /service-area/port-st-lucie
External references cited:
- NOAA National Weather Service Melbourne, Treasure Coast storm advisories Dicor Products and Alpha Systems roofing sealant technical guidance
Final note on the primary service: If you’re searching for rv roof leak repair in Port St Lucie after a storm, is ready today. Call and we’ll roll.
A1 RV Repair
RV repair shop
1961 SW South Macedo Blvd #303, Port St. Lucie, FL 34984
Open now
Monday - Sunday
7 AM–8 PM
Veteran-owned
https://www.facebook.com/a1rvrepair
https://www.instagram.com/a1rvrepair/
https://www.tiktok.com/@a1rvrepair
www.pinterest.com/a1rvrepairservice
https://www.tumblr.com/a1rvrepair
https://www.youtube.com/@A1RVRepair
RV Repair Port St. Lucie FAQ's.
What kind of mobile RV repair services do you offer in Port St. Lucie?.
–We provide full mobile RV repair services that come straight to your location—whether you’re parked at home, in a campground, or stuck on the side of the road. From AC failures to slide-out issues, our skilled team handles everything on-site so you can avoid the headache of moving your RV.
Do you work on motorhomes, or just trailers?
- We work on both! Whether you’ve got a Class A motorhome, a fifth-wheel trailer, or a travel trailer, we’re equipped to handle the job. Our rv technicians know the ins and outs of every style of rig, and we bring the tools and parts and accessories right to you.
What’s included in your maintenance service?
- Our maintenance service covers the basics and beyond: roof resealing, battery testing, water heater inspections, diagnostics, plumbing checkups—you name it. Regular checkups help rv owners catch small issues before they turn into big, costly ones.
What areas do you specialize in when it comes to repairs?
– We specialize in non-engine RV repairs, meaning we’re your go-to for electrical, plumbing, appliances, HVAC, slide-outs, and interior and exterior improvements. Think of us as your all-in-one pit crew for everything but the engine.
Can you deliver replacement parts if I already know what’s wrong?
– Absolutely! If you know your water pump’s toast or your fridge’s circuit board is fried, we can deliver the part, install it, and make sure it’s working perfectly. We work with trusted suppliers to get the right rv parts quickly. Just keep in mind, YOU requested that part and/or service, if that’s not the problem, don’t hold us accountable.
What does your repair process typically look like?
– Our repair process starts with a quick chat to understand your service needs. Once we’re on-site, we run full diagnostics, walk you through what’s going on, and then make the necessary fixes right then and there. It’s all done without the hassle of a service center visit.